tech-sheet-10096828
TECH SHEET 10096828

MODELS 596.70002990, 596.70003990, 596.70004990 and 596.70009990

DISCONNECT POWER CORD BEFORE INSTALLATION SERVICING. IMPORTANT: RECONNECT ALL GROUNDING Clearance must be provided at the top, sides, and rear of the DEVICES refrigerator.

All parts of this appliance capable of conducting AT TOP ………………………………………………………. 1/4 inch electrical current are grounded. If grounding wires, AT SIDES …………………………………………………. 3/16 inch screws, straps, clips, nuts or washers used to AT REAR ………………………………………………….. 1 /4 inch complete a path to ground are removed for ser- vice, they must be returned to original position and The refrigerator must be level. Height may vary according properly fastened. to level adjustment.

ELECTRICAL SPECIFICATIONS CABINET AIR FLOW

Freezer Control (Mid-Position) ………………………. +5° -7°F Refrigerator Air Defrost Control …………………………………………. 8 hr Timer Supply Tunnel to Fresh Food Defrost time 33 ±3.6 min. Compartment Control Defrost Thermostat …………………. Open 55°, Close 20°F Damper Electrical Rating: ……………. 115 VAC, 60 HZ, 5.43 Amps Maximum Current Leakage ………………………….. 0.75 ma Meatkeeper Air Evaporator Maximum Grounding Resistance …………………0.1 Ohms Supply Port Fan *Running Watts ………………. 65° ……………..160 W ±10% Assembly …………………………………….. 90° ……………..165 W ±10% Refrigerator Compressor Locked Rotor Amps ………………. 21.3 Amps Return Air *Avg total watts over entire run cycle Tunnels

Freezer Air Supply Grille

NO LOAD PERFORMANCE

Control Position Mid/Mid and Ambient of:

65°F 90°F Evaporator

Fresh Food °F 37° ±3°F 40° ±3°F Freezer Return Air Frozen Food °F 1° ±3°F 1° ±3°F Through Bottom of Percent Run Time Evaporator Cover 22 ±10% 39 ±10% MACHINE COMPARTMENT AIR FLOW REFRIGERATION SYSTEM

Refrigerant Charge (R134a) ……………………………….7.1 oz Compressor …………………………………………… 850 BTU/Hr

KEY FUNCTIONAL PARTS w/Ohm Reading (where applicable)

Evaporator Fan Motor 12442202 20–40 Condenser Fan Condenser Fan Motor 10884504 130 ±10% Assembly Compressor 12049710 Start 4.35 ±10% Run 2.6 ±10% Compressor Solenoid Valve 12490801 Evaporator Heater 10991104 29 ±10% Damper Control R0161050 Freezer Control C8946703 13100 ±10% Defrost Timer 10530703 Service Drier B2150504 13300 ±10% Return Air Heater 10624901

Drip Pan

Condenser

TECH SHEET 10096828

MODELS 596.70002990, 596.70003990, 596.70004990 and 596.70009990 WATER FLOW DIAGRAM

Water Filter Inlet Water Filter Outlet

Water Filter

Ice Fill Tube

Ice Maker

Water Line Connection

Water Valve

Minimum supply pressure of 35 psig for water filter units is recommended. Minimum pressure requirement is to insure sufficient water volume is available to fill ice maker. Proper fill is 140 cc. of water in 7.5 seconds. Insufficient water volume will cause hollow ice as the result of prema- ture harvest.

TECH SHEET 10096828

MODELS 596.70002990, 596.70003990, 596.70004990 and 596.70009990

TECH SHEET 10096828

MODELS 596.70002990, 596.70003990, 596.70004990 and 596.70009990

FUNCTIONAL PARTS LIST

Part Number Description

C8931608 CAPACITOR, COMPRESSOR RUN 1

12049710 COMPRESSOR 1

10884504 CONDENSER MOTOR 1

12167202 CONDENSER/PAN ASSEMBLY 1

R0161050 DAMPER CONTROL (Includes B834501 Gasket) 1

10530703 DEFROST TIMER 1

B2150504 DRIER, HI-SIDE 1

12442202 EVAPORATOR FAN MOTOR 1

10991104 EVAPORATOR HEATER 1

———- FREEZER HARNESS (FOAMED IN PLACE, NOT REPLACEABLE) 1

C8946703 FREEZER TEMPERATURE CONTROL 1

10456851 GASKET – DOOR, EBONY, FREEZER 1

10456850 GASKET – DOOR, EBONY, REFRIGERATOR 1

10456849 GASKET – DOOR, WHITE, FREEZER 1

10456848 GASKET – DOOR, WHITE, REFRIGERATOR 1

12484602 HARNESS, CONTROL 1

12509501 HARNESS, MACHINE COMPARTMENT 1

________ HARNESS, MULLION (FOAMED IN PLACE, NOT REPLACEABLE) 1

________ HARNESS, REFRIGERATOR LINER (FOAMED IN PLACE, NOT REPLACEABLE) 1

A0282803 LIGHT BULB, FREEZER and REFRIGERATOR 2

C3680310 LIGHT SWITCH, FREEZER and REFRIGERATOR 2

D7714408 LIGHT SOCKET-FREEZER AND REFRIGERATOR 2

R0170047 LOW SIDE ASSEMBLY 1

12180004 MACHINE COMPARTMENT BACK 1

10937034 MANUAL, OWNERS 1

12468201 OVERLOAD-RELAY 1

12086301 POWER CORD 1

10442409 THERMOSTAT, DEFROST 1

10244904 WATER COUPLING 1

12490801 WATER VALVE 1

12388407 FILTER-WATER CARTRIDGE 1

12488101 FILTER-AIR 1