tech-sheet-10096826
TECH SHEET 10096826

MODELS 596.58622990, 596.58627990

DISCONNECT POWER CORD BEFORE INSTALLATION SERVICING. Clearance must be provided at the top, sides, and rear of the IMPORTANT: RECONNECT ALL GROUNDING refrigerator. DEVICES AT TOP ………………………………… 1 inch over hinge cover All parts of this appliance capable of conducting AT SIDES ………………………………………………….. 3/16 inch electrical current are grounded. If grounding wires, AT REAR ………………………………………………………. 1 inch screws, straps, clips, nuts or washers used to complete a path to ground are removed for ser- The refrigerator must be level. Height may vary according vice, they must be returned to original position and to level adjustment. properly fastened. CABINET AIR FLOW

ELECTRICAL SPECIFICATIONS

Freezer Control (Mid-Position) …………………… +13°, -6°F. Defrost Control ……………………………………….. 8 Hr. Timer

Defrost time 33 ±4 min. Defrost Thermostat ……………….. Open 48°F, Close 15°F. Electrical Rating: …………….. 115 VAC, 60 HZ, 9.48 Amps Maximum Current Leakage ………………………….. 0.75 ma Maximum Grounding Resistance ………………… 0.1 Ohms *Running Watts ……………….. 65° …………….173 W. ±10% ……………………………………… 90° …………….183 W. ±10% Compressor Locked Rotor Amps ………………. 25.5 Amps *Avg total watts over entire run cycle

NO LOAD PERFORMANCE

Control Position Mid/Mid and Ambient of:

65°F. 90°F.

Fresh Food °F. 38° ±3°F. 41° ±3°F. Frozen Food °F. 3° ±3°F. 2° ±3°F. Percent Run Time 35 ±10% 63 ±10%

REFRIGERATION SYSTEM

Refrigerant Charge (R134a) ………………………… 5.125 oz. Compressor ………………………………………….. 970 BTU/Hr

KEY FUNCTIONAL PARTS w/Ohm Reading (where applicable)

Evaporator Fan Motor 10513803 23.3–36.3 Condenser Fan Motor 10884501 130 ±10% Compressor 12049706 Start 8.73 ±10% Run 1.88 ±10% Solenoid Valve 12195504 340 ±10% Evaporator Heater 12049801 29 ±10% Damper Control D7547411 Open 42°F Freezer Control R0161092 Defrost Timer 10530703 Period 33 ±3.6 min 8 hour cycle Service Drier B2150504

TECH SHEET 10096826

MODELS 596.58622990, 596.58627990

N WH

DEF TIMER WH WH WH WH WH WH WH WH WH WH WH AUGER WH WH 3 SOL SOL MTR CAV SOL SOL

WH CAP LT 115 VAC CAP UP LW DEF HTR142 REF BR WH REF LT BU VT TN VT/WHGYPTCLTFRZPK BU ORor or BN RDRD/LT RELAY WH BN VT BN YL CRUSH YL CAVITY BK CUBE HTR OR SW

YL BR SPARE WTR ICE WIRE ACT MAKER CNDNSR RD/ YL VT LIGHT SW SENSOR COMP MTR WH S GND EVAP FAN DF YL TERM R ICE C ACT SW YL

BK AUTO LT SW TEMP BR CNTRL BU OVER- REF BK BK BK BK LOAD LT SW RD RD 23 FRZ LT/AUGER 1 INTERLOCK SW

RD RD

H

TECH SHEET 10096826

MODELS 596.58622990, 596.58627990

YL LT BL YL AUTO LT SW BK

YL WH

BK

YL BK GN/YL VT C A V IT Y BKLT GN/YLW ATER BL BK AUGER GN/YLSOL SW BK SW OR WHR E F R IG CUBE CRUSH (W /O L IG H T S E N S O R ) WHLIGHT R E F R IG RD/WH LT SW SW

FRZ LT/AUGER FRZ RD/WH INT ER L O C K S W . LIGHT 312 G N /Y L LOWER TO LIGHT R E F R IG HOUSING VT/WH REF BK WH TO LIGHT LIGHT RD RD WH HOUSING LINER FRZ TOP REF TOP HARNESS VT/WH G R O M M ET GROMMET

FRZ SIDE LOWER RD/WH G R O M M ET R E F R IG WH GROMMET

(AS REQUIRED ON SOME MODELS) W ATER CRISPER LIGHT F ILT E R TAP PLATE WH RD

F R Z H IN G E F Z L IN E R REF GROMMET BACK GROMMET BU DOOR BK GN/YL WH CONNECTOR WH 21 1 LT BU BK YL WH WH RD RD 2 BK LT BU 3 W ATER OR SOL SW 4

H IN G E TO C A V IT Y BN YL WH GN/YL PIN H IN G E HEATER BU AUTO BK BK 2 TO TO ELEC C A V IT Y LT SW BK OR DOOR COVER GROMMET 1 YL LT BU G N /Y L VT 3 RD 2 WH 1

C A V IT Y GN/YL LT BU OR BU LT BU OR RD WH

PK BK AUGER LIGHT BN BK SW SENSOR YL

CUBE CRUSH

FREEZER DOOR SW ( A S S H O W N W /L I G H T S E N S O R , S E E A B O V E W / O )

BU RD TEMP OR CNTRL

BU WH CAP YL OR G N /Y L WH C A B IN E T H A R N E S S G N /Y L REF OC BACK GROMMET WH G N /Y L G N /Y L 1 G N /Y L 3 1 1 4 TO 2 CNTRL 3 WH 3 WH AUTOMATIC ICE BRKT 4 RD FUSE 4 RD MAKER

2 TN 2 TN EVAPORATO R YL RD OC BACK FAN BR RD TN L1 AUGER MTR DEFROST AMP PVC RD WH G N /Y L HEATER CONNECTOR SLEEVE WH BK OC BACK L3 OR BK L2 BR WH FRZ 115 VAC DEFROST OC BACK 60 HZ T E R M IN A T O R GROMMET LT BU S E R V IC E WH MACH COMP HARNESS DEFROST ML K J HGF E DC BA 123 1 234 1 23 12 T IM E R BK

BK LT BU GY RUN WH 3 41 2 YL WH CAP. BR TN

CONDENS ER FAN WH (AS REQUIRED ON MOTOR BU SOME MODELS) YL RUN CAP. BR GY 3 S BU WH WH WH C OVERLOAD WH BU or VT BK SPLICE WH W ATER P R IM A R Y R TN or BN ICE SOLENOID 2 WH COMP VALVE

WH PTC

RELAY

RELAY FENCE G N /Y L BASE WH PAN VT BN W ATER SECONDARY WH ICE SOLENOID VALVE

(AS REQUIRED ON SOME MODELS) SECONDARY WATER FILTER VALVE

1 2 4 2 5 8 0 4 P R I N T E D IN U .S . A .

TECH SHEET 10096826

MODELS 596.58622990, 596.58627990

FUNCTIONAL PARTS LIST

Part Number Description

C8931604 CAPACITOR, AUGER MOTOR 1

12049706 COMPRESSOR 1

10518702 CONDENSER FAN BLADE 1

10884501 CONDENSER MOTOR 1

10544110 CONDENSER/PAN ASSEMBLY 1

D7547411 DAMPER CONTROL 1

10530703 DEFROST TIMER 1

B2150504 DRIER, HI-SIDE 1

10890101 EVAPORATOR FAN BLADE 1

10513803 EVAPORATOR FAN MOTOR 1

12049801 EVAPORATOR HEATER 1

12023401 FILL TUBE ASSEMBLY 1

R0161092 FREEZER TEMPERATURE CONTROL 1

R9800047 GASKET–DOOR, WHITE, FREEZER 1

R9800046 GASKET–DOOR, WHITE, REFRIGERATOR 1

A0282803 LIGHT BULB, REFRIGERATOR/FREEZER 2

M0360001 LIGHT BULB, CAVITY 1

D7714407 LIGHT SOCKET, FREEZER 1

C8973406 LIGHT SOCKET, REFRIGERATOR 1

R0170055 LOW SIDE ASSEMBLY 1

12041616 MACHINE COMPARTMENT BACK ASSEMBLY 1

10894809 MANUAL, OWNERS 1

10114805 MOTOR AUGER 1

12433201 MUFFLER ASSEMBLY 1

10377023 OVERLOAD 1

10916505 POWER CORD 1

10097202 RELAY–PTC 1

C3680312 SWITCH, AUGER MOTOR INTERLOCK/FREEZER LIGHT 1

12419601 SWITCH, LIMIT 4

10166101 SWITCH, LIGHT 1

C3680308 SWITCH, LIGHT REFRIGERATOR 1

10166002 SWITCH, CRUSHED/CUBED 1

12017823 THERMOSTAT, DEFROST 1

10244904 WATER COUPLING 1

10988502 WATER TANK 1

12195504 WATER VALVE 1

12072602 WIRING HARNESS, CABINET 1

12432002 WIRING HARNESS HEATER, FREEEZER DOOR 1

D7824601 WIRING HARNESS, ICE MAKER 1

10967602 WIRING HARNESS, MACHINE COMPARTMENT 1