tech-sheet-10096813
TECH SHEET 10096813

MODELS 596.57085790, 596.57089790, 596.57082790, 596.57087790

DISCONNECT POWER CORD BEFORE INSTALLATION SERVICING. Clearance must be provided at the top, sides, and rear of the IMPORTANT: RECONNECT ALL GROUNDING refrigerator. DEVICES AT TOP ……………………………….. 1 inch over hinge cover All parts of this appliance capable of conducting AT SIDES …………………………………………………. 3/16 inch electrical current are grounded. If grounding wires, AT REAR ………………………………………………………. 1 inch screws, straps, clips, nuts or washers used to complete a path to ground are removed for ser- The refrigerator must be level. Height may vary according vice, they must be returned to original position and to level adjustment. properly fastened.

ELECTRICAL SPECIFICATIONS CABINET AIR FLOW

Freezer Control (Mid-Position) ……………….. +13.3°, -7°F. FREEZER BACK REFRIGERATOR AIR Defrost Control ………………………………… 115 VAC, 60 Hz (AIR BAFFLE) SUPPLY TUNNEL Defrost Thermostat ………………… Open 48°, Close 25°F. TO FRESH FOOD Electrical Rating: ……………. 115 VAC, 60 Hz, 9.48 Amps COMPARTMENT CONTROLS Maximum Current Leakage ………………………….. 0.75 ma Maximum Grounding Resistance ………………… 0.1 Ohms *Running Watts ………………. 65° …………….160 W. ±10% …………………………………….. 90° …………….160 W. ±10% Compressor Locked Rotor Amps ………………. 21.3 Amps *Avg total running watts

NO LOAD PERFORMANCE MEATKEEPER AIR SUPPLY Control Position Mid/Mid and Ambient of: REFRIGERATOR AIR 65°F. 90°F. EVAPORATOR RETURN TUNNEL FAN ASSEMBLY Fresh Food °F. 39° ±3°F. 40° ±3°F. CONDENSER FAN Frozen Food °F. 1° ±3°F. 1° ±3°F. ASSEMBLY Percent Run Time 30 ±10% 52 ±10% COMPRESSOR

REFRIGERATION SYSTEM EVAPORATOR

Refrigerant Charge (R134a) ………………………… 5.125 oz. Compressor ………………………………………….. 850 BTU/Hr

KEY FUNCTIONAL PARTS w/Ohm Reading (where applicable)

Evaporator Fan Motor 10513803 23.3–36.3 CONDENSER Condenser Fan Motor 10884501 220 Compressor 12049703 Start 4.35 ±10% Run 2.6 ±10% Solenoid Valve D7742203 345 ±10% Cavity Heater 10882106 6610 ±10% Evaporator Heater 12049801 29 ±10% Damper Control D7547411 Freezer Control C3615024 Service Drier B2150504

TECH SHEET 10096813

MODELS 596.57085790, 596.57089790, 596.57082790, 596.57087790

ADAPTIVE DEFROST Adaptive defrost control seeks 21 to 24 minutes defrost cycle by varying the compressor cumulative run time between defrost cycles. Compressor run time will be 8, 12, or 16 hours. Defrost time will not exceed 29 minutes. To force defrost cycle, with compressor running and one compartment door closed, press either door light switch 4 times within 8 seconds.

Input voltage readings and checks L1 to L2 line voltage should be present when unit is powered. K to L2 line voltage should be present with cold control contacts closed. T to L2 line voltage should be present when cold control contacts are closed, defrost terminator is closed and adaptive defrost control is in defrost mode. R to L2 line voltage should be present with refrigerator door open (door light switch is closed). F to L2 line voltage should be present with freezer door open (door light switch is closed).

Output voltage readings and checks C to L2 line voltage should be present when in refrigeration mode with cold control contacts closed. D to L2 line voltage present when in defrost mode with cold control contacts closed.

TECH SHEET 10096813

MODELS 596.57085790, 596.57089790, 596.57082790, 596.57087790

12350001 REV 00 PRINTED IN U.S.A.

TECH SHEET 10096813

MODELS 596.57085790, 596.57089790, 596.57082790, 596.57087790

FUNCTIONAL PARTS LIST

Part Number Description Qty

12026002 CABINET HARNESS 1 C8931604 CAPACITOR, COMPRESSOR RUN 1 C8931605 CAPACITOR, AUGER MOTOR 1 10882106 CAVITY HEATER 1 12049703 COMPRESSOR 1 10884501 CONDENSER MOTOR 1 10883403 CONDENSER/PAN ASSEMBLY 1 D7547411 DAMPER CONTROL 1 12050504 DEFROST, ADAPTIVE CONTROL 1 B2150504 DRIER, HI-SIDE 1 10513803 EVAPORATOR FAN MOTOR 1 10890101 EVAPORATOR FAN BLADE 1 12049801 EVAPORATOR HEATER 1 12023401 FILL TUBE ASSEMBLY 1 M0360001 FREEZER, LIGHT BULB 1 ———- FREEZER HARNESS (FOAMED IN PLACE, NOT REPLACEABLE) 1 D7714407 FREEZER, LIGHT SOCKET 1 C3680304 FREEZER, LIGHT SWITCH 1 C3615024 FREEZER TEMPERATURE CONTROL 1 10359709 GASKET – DOOR, WHITE, FREEZER 1 10359708 GASKET – DOOR, WHITE, REFRIGERATOR 1 10535701 HARNESS, REFRIGERATOR LINER (FOAMED IN PLACE, NOT REPLACEABLE) 1 A0282803 LIGHT BULB, REFRIGERATOR 3 C3680305 LIGHT SWITCH, REFRIGERATOR 2 R0170055 LOW SIDE ASSEMBLY (CONSISTING OF EVAPORATOR, PN 10539301, AND HEAT EXCHANGER, PN 10599003) 1 D7788912 MACHINE COMPARTMENT BACK ASSEMBLY 1 10894806 MANUAL, OWNERS 1 10114804 MOTOR, AUGER 1 10377015 OVERLOAD 1 10678503 POWER CORD 1 12156201 REFRIGERATOR LIGHT SOCKET 1 10097202 RELAY-PTC 1 12017815 THERMOSTAT, DEFROST 1 ———- VERTICAL MULLION (NOT REPLACEABLE) 10244903 WATER COUPLING 1 10988502 WATER TANK 1 D7742203 WATER VALVE 1